Teufelberger (New England Ropes)
The #1 double braid in America. A strong, flexible, and long wearing line. Great for a wide range of boats for sheets and control lines.
Very little degradation from sunlight. Can be used outside over long term if inspected regularly.
Polyester has good resistance to most chemicals except 95% sulfuric acid and strong alkalines at boil. HMPE has good resistance to most minerals, organics, acids, and weak alkalines. HMPE also has excellent resistance to bleaches and other oxidizing agen
Polyester melts at 480°F with progressive strength loss above 300°F.
Good resistance to the passage of electrical current. However, dirt, surface contaminants, water entrapment, and the like can significantly affect dielectric properties. Extreme caution should be exercised any time a rope is in the proximity of live circuits.
Recommended sheave diameter to rope diameter is 8:1.
No blanket safe working load (SWL) recommendations can be made for any line because SWL's must be calculated based on application, conditions of use, and potential danger to personnel among other considerations. It is recommended that the end user establish working loads and safety factors based on best practices established by the end user's industry; by professional judgment and personal experience; and after thorough assessment of all risks. The SWL is a guideline for the use of a rope in good condition for non-critical applications and should be reduced where life, limb, or valuable property is involved, or in cases of exceptional service such as shock loading, sustained loading, severe vibration, etc. The Cordage Institute specifies that the SWL of a rope shall be determined by dividing the Minimum Tensile Strength of the rope by a safety factor. The safety factor ranges from 5 to 12 for non-critical uses and is typically set at 15 for life lines.
Double Braid Eye Splice
I have used several spools of this line to make halters for horses. It is great.
I use the halters on everything from colts to 2000 pound draft horses. Only one halter broke to date and that one caught on a sharp edge. Not only is the line stronger than what is typically sold in the hardware store but you can use a lighter line which fits under a headstall and the lighter line "bites" a little more when the horses pull back so they learn quickly not to.
I just needed some good quality lighter weight rope and this stuff fit the bill. I haven't used it yet, but it seems fine. It's rope... what's not to like?